325C Excavator Fuses - Replace Caterpillar


Fuses - Replace
`
325C Excavator [SEBU7454]
ELECTRICAL AND STARTING SYSTEM
BATTERY GP
325C Excavator Fuses - Replace
325C Excavator Fuses - Replace

Open the access door on the left side of the machine.

The fuse panel is located on the circuit breaker panel. Open the access cover for fuse access.


Fuses - Fuses protect the electrical system from damage that is caused by overloaded circuits. Change a fuse if the element separates. If the element of a new fuse separates, check the circuit and/or repair the circuit.


NOTICE

Always replace fuses with the same type and capacity fuse that was removed. Otherwise, electrical damage could result.



NOTICE

If it is necessary to replace fuses frequently, an electrical problem may exist.

Contact your AVSpare dealer.


To replace a fuse, use the puller that is stored in the fuse panel. Three fuses of 5 Amperes, six fuses of 10 Amperes, three fuses of 15 Amperes, and two fuses of 30 Amperes are contained in the fuse panel as spare fuses.

The following list identifies the circuits that are protected by each fuse. The amperage for each fuse is included with each circuit.




Illustration 1g00811489

(1) Spare - 5 Amp

(2) Spare - 10 Amp

(3) Spare - 10 Amp

(4) Spare - 10 Amp

(5) Spare - 15 Amp

(6) Spare - 15 Amp

(7) Spare - 30 Amp

(8) Engine Controller - 15 Amp

(9) Horn - 10 Amp

(10) Timer Relay - 10 Amp

(11) Cab Light - 10 Amp

(12) Engine Start Switch - 10 Amp

(13) Boom Light - 10 Amp

(14) Engine Controller and Pump Controller - 10 Amp

(15) Controller for Attachment Valve - 15 Amp

(16) Cab Dome Light and Radio Memory - 10 Amp

(17) Heater and Air conditioner Blower Fan - 15 Amp

(18) Electric Refueling Pump - 30 Amp

(19) Spare - 5 Amp

(20) Spare - 5 Amp

(21) Spare - 10 Amp

(22) Spare - 10 Amp

(23) Fuel Pump - 5 Amp

(24) Windshield Washer and Windshield Wiper - 10 Amp

(25) Chassis Light - 10 Amp

(26) Backup Switches and Monitor Controller - 5 Amp

(27) Seat Heater - 5 Amp

(28) Lower Windshield Washer and Lower Windshield Wiper - 10 Amp

(29) Cigar Lighter - 10 Amp

(30) Switch Panel and Radio - 5 Amp

(31) Attachment Solenoid - 10 Amp

(32) 12 Volt 7 Amp Converter 1 - 10 Amp

(33) 12 Volt 7 Amp Converter 2 - 10 Amp

(34) Air Conditioner or Cab Heater - 15 Amp

(35) Quick Coupler - 5 Amp

(36) Power Window - 15 Amp

(37) Cab Fan - 5 Amp

(38) Auxiliary Circuit - 10 Amp

Information System:

325C and 325C L Excavator Fuel System Filter - Replace
325C and 325C L Excavator Engine Oil and Filter - Change
3064 and 3066 Engines for Caterpillar Built Machines Fuel Injection Timing - Check
325C and 325C L Excavator Engine Oil Level - Check
2002/05/06 New High Temperature Buffer Seals Reduce Oil Leakage From Hydraulic Cylinders {7562}
312C Excavator 3064 Engine Supplement Turbocharger - Install
320C U Excavator Securing the Machine
325C and 325C L Excavator Engine and Machine Warm-Up
325C Excavator Engine Starting with Ether Starting Aid - If Equipped
325C and 325C L Excavator Hydraulic Lockout Control
312C Excavator 3064 Engine Supplement Air Inlet Heater - Remove and Install
325C and 325C L Excavator Engine Starting
Starting Motor Solenoid - Replace {1467}
325C and 325C L Excavator Hydraulic System Oil Filter (Case Drain) - Replace
325C and 325C L Excavator Hydraulic System Oil Filter (Pilot) - Replace
3064 and 3066 Engines for Caterpillar Built Machines Low Idle RPM - Adjust
HDB Series and M1 Series Heavy Duty Brushless Alternators General Information
312C Excavator 3064 Engine Supplement Air Cleaner - Remove and Install
HDB Series and M1 Series Heavy Duty Brushless Alternators Normal Operation
3064 and 3066 Engines for Caterpillar Built Machines Engine Valve Lash - Inspect/Adjust
3064 and 3066 Engines for Caterpillar Built Machines Engine Oil Pressure - Test
914G Compact Wheel Loader and IT14G Integrated Toolcarrier Transmission Electronic Control System Using Caterpillar Electronic Technician to Determine Diagnostic Codes
3064 and 3066 Engines for Caterpillar Built Machines Cooling System - Test
3500B Engines for 5130B and 5230B Excavators System Overview