Diagnostic Code List
`
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
[RENR5558]
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Diagnostic Capabilities
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Diagnostic Operation
ELECTRICAL AND STARTING SYSTEM
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Diagnostic Capabilities
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Diagnostic Code List
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Introduction
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
System Schematic
When the ECM detects an abnormal condition for a certain component in the system, a diagnostic code will be activated for the component. When the ECM activates a diagnostic code for your machine, refer to the corresponding procedure in the Troubleshooting section of this manual for the specific troubleshooting procedure.
The following diagnostic code list is for machines with serial number ranges:
- BEB1-2000
- BDK1-2000
- BDM1-2000
- BDR1-2000
- BDX1-2000
- BDY1-2000
- BCZ1-2000
Show/hide table
| Diagnostic Codes For The Machine ECM MID 039 |
|
|---|---|
| CID 0096 Fuel Level Sensor | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 04 | Voltage below normal, shorted low |
| CID 0127 Transmission Pressure Sensor | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 04 | Voltage below normal, shorted low |
| CID 0291 Solenoid (Engine Cooling Fan) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 0298 Switch (Service Brake Pedal) | |
| FMI 04 | Voltage below normal, shorted low |
| FMI 05 | Current below normal, open circuit |
| CID 0374 Solenoid Valve (Swing Brake) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 0376 Travel Alarm | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 0444 Magnetic Switch (Start Relay) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 0590 Engine Electronic Control Module (ECM) | |
| FMI 02 | Incorrect, intermittent, erratic data |
| FMI 09 | Abnormal update |
| FMI 12 | Bad device or component |
| CID 0598 Solenoid Valve (Travel Speed) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 0600 Hydraulic Oil Temperature Sensor | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 04 | Voltage below normal, shorted low |
| CID 0681 Solenoid Valve (Parking Brake) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 0736 Signal for Automatic Engine Speed Control | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 06 | Current above normal, grounded circuit |
| CID 0882 Solenoid Valve (Hydraulic Activation) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1180 Solenoid (Auxiliary Hydraulic Number 1) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Voltage below normal, shorted low |
| FMI 06 | Current above normal, grounded circuit |
| CID 1181 Solenoid (Auxiliary Hydraulic Number 2) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Voltage below normal, shorted low |
| FMI 06 | Current above normal, grounded circuit |
| CID 1486 Solenoid Valve (Creeper Speed) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1530 Solenoid Valve (Quick Coupler) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1615 Solenoid Valve (One-Way Flow or Two-Way Flow) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1616 Solenoid Valve (Stabilizer) (High Pressure Solenoid) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1617 Solenoid Valve (Oscillating Axle) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1618 Position Sensor (Swashplate Angle) | |
| FMI 00 | Data Above normal range |
| FMI 01 | Data Below normal range |
| FMI 03 | Voltage above normal, shorted high |
| FMI 04 | Voltage below normal, shorted low |
| CID 1621 Solenoid Valve (Generator) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1622 Travel Lock Magnet | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1623 Brake Lights | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1624 Solenoid (Travel) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1628 Armrest Switch | |
| FMI 04 | Voltage below normal, shorted low |
| FMI 05 | Current below normal, open circuit |
| CID 1629 Solenoid (Power Shift Pressure for the Main Pump) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1630 Solenoid (Swing Pump) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1670 Limit Switch (Travel Pedal) | |
| FMI 04 | Voltage below normal, shorted low |
| FMI 05 | Current below normal, open circuit |
| CID 1683 Relay (Refueling Pump) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1739 Solenoid (Hammer) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
The following diagnostic code list is for machines with serial number ranges:
- (BDX2001-UP)
- (BCZ2001-UP)
- (BEB2001-UP)
- (BDK2001-UP)
- (BDY2001-UP)
- (BDR2001-UP)
- (BDM2001-UP)
- (H2A1-UP)
- (H2B1-UP)
- (H2C1-UP)
- (H2D1-UP)
- (H2E1-UP)
- (H2F1-UP)
- (H2G1-UP)
Show/hide table
| Diagnostic Codes For The Machine ECM MID 039 |
|
|---|---|
| CID 0096 Fuel Level Sensor | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 04 | Voltage below normal, shorted low |
| CID 0127 Transmission Pressure Sensor | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 04 | Voltage below normal, shorted low |
| CID0191 Transmission Output Speed Sensor | |
| FMI 02 | Data erratic, intermittent or incorrect |
| FMI 11 | Failure mode not identifiable |
| CID 0291 Solenoid (Engine Cooling Fan) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 0298 Switch (Service Brake Pedal) | |
| FMI 04 | Voltage below normal, shorted low |
| FMI 05 | Current below normal, open circuit |
| CID 0374 Solenoid Valve (Swing Brake) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 0444 Magnetic Switch (Start Relay) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 0600 Hydraulic Oil Temperature Sensor | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 04 | Voltage below normal, shorted low |
| CID 0727 Medium Pressure Hydraulic Solenoid No. 2 | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 0882 Solenoid Valve (Hydraulic Activation) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1130 Auxiliary Pedal Position Sensor | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 04 | Voltage below normal, shorted low |
| CID 1401 Transmission Solenoid No. 1 | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1402 Transmission Solenoid No. 2 | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1530 Solenoid Valve (Quick Coupler) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1615 Solenoid Valve (One-Way Flow or Two-Way Flow) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1617 Solenoid Valve (Oscillating Axle) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1621 Solenoid Valve (Generator) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1622 Travel Lock Magnet | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1623 Brake Lights | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1628 Armrest Switch | |
| FMI 04 | Voltage below normal, shorted low |
| FMI 05 | Current below normal, open circuit |
| CID 1629 Solenoid (Power Shift Pressure for the Main Pump) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1630 Solenoid (Swing Pump) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1657 Right Joystick Thumbwheel | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 04 | Voltage below normal, shorted low |
| CID 1670 Travel Pedal Limit Switch | |
| FMI 04 | Voltage below normal, shorted low |
| FMI 05 | Current below normal, open circuit |
| CID 1739 Solenoid (Hammer) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1842 Auxiliary Valve Pressure Solenoid (Aux Sol. No. 2) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 1843 Auxiliary Valve Flow Solenoid (Aux Sol. No. 1) | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 2104 Travel Motor Swash Plate Angle Limit Solenoid | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 2142 Straight Travel Pedal Position Sensor | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 04 | Voltage below normal, shorted low |
| CID 2149 Travel Pilot Pressure Solenoid | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 2184 Medium Pressure Hydraulic Solenoid No. 1 | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 2198 Medium Pressure Switches No. 1, No. 2, No. 3 | |
| FMI 02 | Data erratic, intermittent or incorrect |
| CID 2256 Hydraulic Modulation Solenoid | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
| CID 2447 Travel Motor Bypass Solenoid | |
| FMI 03 | Voltage above normal, shorted high |
| FMI 05 | Current below normal, open circuit |
| FMI 06 | Current above normal, grounded circuit |
Information System:
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Diagnostic Capabilities
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Configuration Menu
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Brake Light Function
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Auxiliary Hydraulic System
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Automatic Engine Speed Control Function
312C Excavator Machine Systems
Bucket Linkage - Install
312C Excavator Machine Systems
Bucket Linkage - Remove
446B Backhoe Loader Transmission (Autoshift)
Transmission and Torque Converter - Test
5230B Excavator Electronic Systems Guide
Component Location Overview
5230B Excavator Electronic Systems Guide
Location of Electronic Control Modules
2002/04/08
New Assembly Instructions for Rod Seals on Hydraulic Cylinders are Available {7562}
314C Excavator Excavator Systems
Bucket - Remove
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Diagnostic Operation
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Electronic Control Module (ECM)
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Filter Fluid Hours Menu
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Gauges
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
General Information (Monitoring System)
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Generator Function
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Glossary of Terms
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Hydraulic Activation Control Function
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Introduction
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
Logged Events Menu
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
MID 039 - CID 0291 - FMI 03
M313C, M315C, M316C, M318C, M318C MH, M322C and M322C MH Excavators Electronic System
MID 039 - CID 0291 - FMI 05