3500B and 3500B High Displacement Generator Set Engines E017 High Engine Coolant Temperature Warning Caterpillar


E017 High Engine Coolant Temperature Warning
`
3500B and 3500B High Displacement Generator Set Engines [RENR2209]
Event E017

Conditions Which Generate This Code:

The Electronic Control Module (ECM) detects engine coolant temperature that is greater than the default temperature of 102 °C (216 °F) for five seconds.

System Response:

The event is logged. After the temperature returns below 97 °C (207 °F) the warning due to high coolant temperature will be turned off.

Possible Performance Effect:

  • None

Troubleshooting:

  • There may be a problem with the cooling system.

  • There may be a problem with the coolant temperature sensor.

Test Step 1. Check for "ACTIVE" Diagnostic Codes.

  1. Start the AVSpare Electronic Technician (ET).

  2. Turn the keyswitch to the ON position.

  3. Check for any active diagnostic codes or for logged diagnostic codes.

Expected Result:

No diagnostic codes are present.

Results:

  • OK - No diagnostic codes are present. Proceed to Test Step 2.

  • Not OK - Diagnostic codes are present.

    Repair: Repair the diagnostic codes that are present. Refer to the appropriate topic in the "Troubleshooting With a Diagnostic Code" section of this manual. Ensure that the repair eliminates the problem.

    STOP

Test Step 2. Perform a Check of the Cooling System.

  1. Perform a check of the cooling system. Refer to the diagnostic procedure Troubleshooting, "Coolant Temperature is Too High" for possible causes.

Expected Result:

There are no problems with the cooling system.

Results:

  • OK - There may be an intermittent problem.

    Repair: Monitor the operation of the engine. Repair the problem. Ensure that the repair eliminates the problem.

    STOP

  • Not OK - There is a problem with the cooling system.

    Repair: Repair the problem. Ensure that the repair eliminates the problem.

    STOP

Information System:

325C Excavator Machine System Specifications Stick - M3.2C
325C Excavator Machine System Specifications Stick - M2.5D
5130B Excavator Hydraulic System Pilot Hydraulic System
2001/09/24 New Main Bearings Provide Improved Bearing Retention in the Cylinder Block {1203}
312C, 315C, 318C, 319C, 320C, 321C, 322C, 325C, 330C and M325C Excavators and 325C MHPU and 330C MHPU Mobile Hydraulic Power Units Engine and Pump Control - V2 Check of Governor Actuator - Troubleshoot - CID 91 - 315C, 318C, 319C, 320C, 321C, And 322C
315C Excavator Engine Speed Control
305 CR Mini Hydraulic Excavator Engine Oil and Filter - Change
M315 Excavator Hydraulic System Engine Speed - Test and Adjust - No Load
CS44 and CP44 Soil Compactor Machine System Vibratory Support
M315 Excavator Hydraulic System Engine Performance - Test
305 CR Mini Hydraulic Excavator Engine Oil Level - Check
325C Excavator Machine System Specifications Boom - 6150 mm (242.1 inch)
312C and 312C L Excavator Lifting Capacities - 312C L with a Reach Boom and No Blade
3500B Engines for 776D, 777D, 784C, 785C, 789C and 793C Off-Highway Trucks E021 High Exhaust Temperature Derate
325C Excavator Machine System Specifications Stick
312C and 312C L Excavator Joystick Controls
345B, 345B Series II and W345B Series II Excavators Engine and Pump Control No Power Supply to Controller - Troubleshoot
345B, 345B Series II and W345B Series II Excavators Engine and Pump Control Fuel Gauge Indication Is Abnormal - Troubleshoot - 420A and 420B
345B, 345B Series II and W345B Series II Excavators Engine and Pump Control Hydraulic Oil Temperature Gauge Indication Is Abnormal - Troubleshoot - 4203
325C Excavator Machine System Specifications Stick
312C, 315C, 318C, 319C, 320C, 321C, 322C, 325C, 330C and M325C Excavators and 325C MHPU and 330C MHPU Mobile Hydraulic Power Units Engine and Pump Control - V2 Engine Controller Is Abnormal - Troubleshoot - 590
305 CR Mini Hydraulic Excavator Fuses - Replace
3500B Engines for 776D, 777D, 784C, 785C, 789C and 793C Off-Highway Trucks E095 Fuel Filter Restriction Warning
325C Excavator Machine System Specifications Stick